Welcome Guest. ( logon | register ) | ||||||
|
|
|
| Topic Tools | Message Format |
Author |
| ||
Ertech Veteran Date registered: May 2016 Location: Montreal CA Vehicle(s): 2011 G550 Posts: 156 | Tuneup suggestions?? Hi guys working on my " new 2002 g500" I am changing all fluids , air/ fuel cabin filters , greasing all needed points What else do you guys suggest to do? Car has 130000mi no history Should i do plugs and wires?? What else? Thanks guys Erick | ||
#233009 | |||
Author |
| ||
Otiswesty Administrator Date registered: Jun 2007 Location: Portland, Oregon Vehicle(s): 463.241, 461.213 Posts: 3006 | Re: Tuneup suggestions?? Pull and lube the center drive shaft CV joints. MOST IMPORTANT! Plugs are a good idea, should be every 60K. Change the idler pulley and the tensioner pulley as well. I recommend the G-wagenaccesories.com aluminum pulleys. It is not a bad idea to swap out the crank position sensor and keep the used one as a known good spare (or just buy two of them) Under the plastic engine cover, smaller front portion, there is a 2-3 mm hard plastic vacuum tube that can wear through and trigger fault codes and result in rough idle. | ||
#233013 - in reply to #233009 | |||
Author |
| ||
Ertech Veteran Date registered: May 2016 Location: Montreal CA Vehicle(s): 2011 G550 Posts: 156 | Re: Tuneup suggestions?? Perfect will folow your advice | ||
#233016 - in reply to #233013 | |||
Author |
| ||
460332 Date registered: Apr 2006 Location: Europe Vehicle(s): | Re: Tuneup suggestions?? - Power steering oil and filter? - Did you do the brake fluid in the differential locks? - Check the content/fill the front axle shaft housing with grease. The specs when empty are 400 gram/1 tube each side. - Check the wheel bearings for slack. - Brake fluid within specs? Brake pads? No rust on brake lines? - Inspect front and rear axle rubber bearings. - Air condition service? New dryer if it towards full? - Air condition treatment against bacteria, fungi and spores. - Lubricate all moving contact points on brake calipers with ATE PlastiLube (also against squealing). 100.000 km service point. - Injection treatment? - Touch-up paint on chips and scratches. Use a sharp toothpick on the small chips!! - small drop of lock-oil for ignition lock - use well known brand, even though MB says it is not necessary. - Greasing needed point - Do you lubricate all door hinges, hood hinges, door locks, i.e any moving part that need oil? Buy some thin PTFE (Teflon) spray that thickens when the solvent evaporate. I lubricate wires/hood locks, pedal links, seat slides, etc. - Use silicone oil to lubricate the doors rubber sealing. - Refresh rubber parts on the body with some back to black stuff. - Check your spare tire's air pressure. - Check the weight of the battery fluid. Top-charge if necessary. - Polish the car to remove the oxide in the paint - prevents rust etc. Edited by 460332 7/16/2016 3:35 PM | ||
#233017 - in reply to #233009 | |||
Author |
| ||
Otiswesty Administrator Date registered: Jun 2007 Location: Portland, Oregon Vehicle(s): 463.241, 461.213 Posts: 3006 | Re: Tuneup suggestions?? Most important is to spend your weekends driving the car to interesting places, and then work on this stuff when the weather is not as nice | ||
#233054 - in reply to #233009 | |||
« View previous thread :: View next thread » |
|
|